SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH INSTALLATION / OWNER’S MANUAL SCHWANK GAS FIRED SEB/SEBU SERIES LOW INTENSITY TUBE T
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH 7. SUSPENSION SYSTEM The system configuration and available support locations must be considered
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 7 FIGURE 5 SEBU TYPICAL HANGER & SUPPORT SPACING 5 Alumatherm Tube with Flange 6 T
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 8 8. BURNER AND TUBE INSTALLATION With all hangers suspended at the same height, insert first
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH 1. Reflectors 2. 900 Elbow 3. End of Swaged Tube (fully inserted) 4. Couplers 9. REFLEC
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 10 TABLE 4 MODEL TURBULATOR LENGTH (IF REQUIRED) SEB 200-70/60/50 10’ SEB 1
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 11 10. FLUE VENTING The SEB/SEBU series is approved for both direct vented and indirect vented
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 12 PLEASE SEE SECTION 13 PAGE 15: HEATER EXPANSION The total maximum allowable length o
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 13 If drawing in fresh air from outside, it is rec-ommended as per common Engineering prac-tice
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 14 DO NOT use pressures greater than 1/2 psig. to pressure check the heater. TEST FOR LEAKS:
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 15 13. HEATER EXPANSION Due to the characteristics of tube heaters, the installer must allow fo
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH NOTICE: Schwank Inc., reserves the right to make changes to equipment and specifications without ob
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 16 Each individual tube heater requires 120Volts 60 Hz electrical power sized for 145VA. The he
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 17 16. SEQUENCE OF OPERATION / FLAME RECOVERY/ SAFETY LOCKOUT Start up - Heat Mode When the th
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 20 Page 18 17. LIGHTING INSTRUCTIONS Refer to the lighting instructions on the inside cover of
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 19 19. CA SERIES WIRING DIAGRAM 12OV THERMOSTAT
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 20 YES YES YES 20. TROUBLESHOOTING GUIDE - 120v THERMOSTAT SET THERMOSTAT TO CALL FOR HEAT COMB
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 21 SPARK STOPS WHEN BURNER LIGHTS SYSTEM RUNS UNTIL CALL FOR HEAT ENDS CALL FOR HEAT ENDS: S
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 22 21. SPARK IGNITION CIRCUIT The step-up transformer in the ignition control provides spark ig
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH 22. START-UP SHEET Page 23 COMMISSIONING REPORT CONTRACTOR
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 24 TYPE OF GAS: NG LP DOES BUILDING HAVE A NEGATIVE CONDITION: YES NOIF THIS IS A HIGH ALTI
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH 23. OPTIONAL COMPONENTS: FOR SCHWANK SE SERIES TUBE HEATERS Flue Vent Terminals 4” wall hori
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH SEB/SEBU INFRA-RED GAS TUBE HEATERS TABLE OF CONTENTS TOPIC PAGE NUMBE
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 26 90 degree Aluminized Steel Elbow Kit* (*Kit includes: elbow, coupler, and two end plate h
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH TruTemp Thermostat (Do Not use in wet or corrosive environments) JM-0150-XX JS-0569-X
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Hanging Chain - (box of 50 ft) JL-0798-XX JA-0587-XX JA-0780-XX
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 29 MODEL NO STD ORIFICE (DMS) FOR USE AT ALTITUDES ABOVE (FEET) 2000 3000 4000 5000 6000
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH LIMITATIONS AND EXCLUSIONS This document contains all warranties made by the Manufacturer and may no
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 1 SCHWANK GAS INFRA-RED TUBE HEATER SEB/SEB(U) SERIES INSTALLATION INSTRUCTIONS Page 1 It is re
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH *Manufactured and shipped in 10’ lengths. Due to the swaged overlap total lengths are slightly short
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 3 4. PRE-INSTALLATION SURVEY The Schwank SEB /SEBU heating system must have gas piping of the
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH Page 4 SEBU 200 7" 22" 68" 7" 1" 57" 68" SEBU 175 6.5"
SP-MSEB-BX-10A SEB Manual RD: JUNE 2004 RL: 10 KH 6. SYSTEMS INCORPORATING 90O ELBOWS The SEB Series radiant tube heater can be in-stalled in confi
Comments to this Manuals